Product ID:BREAKTHRU GLOSS-CLEAR VARNISH, 70-0
MSDS Date:01/01/1996
FSC:8010
NIIN:00N082425
MSDS Number: CGCWV

VANEX INC

1700 S SHAWNEE ST
MT VERNON, IL 62864
US

Emergency Phone: 618-244-1416

Info Phone: 800-851-7390

Preparer: CHRIS CAMPBELL

Cage: HO962

VANEX INC

MT VERNON, IL 62864 US

Telephone: 800-851-7390

Cage: HO962

0.6 @ 68F

CAS: 111-76-2

RTECS: KJ8575000

Fraction By Weight: 10%

OSHA PEL 50 PPM, S

ACGIH TLV: 25 PPM, S

PHTHALIC ACID, DIBUTYL ESTER; (DIBUTYL PHTHALATE) (SARA

CAS: 84-74-2

RTECS: TI0875000

Fraction By Weight: 3-8%

OSHA PEL 5 MG/M3

ACGIH TLV: 5 MG/M3

EPA Report Quantity: 10 LBS

DOT Report Quantity: 10 LBS

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE: INHAL: VAPS MAY IRRITATE NOSE,
THROAT & RESP PASSAGES. HIGHER CONCS CAN INDUCE HDCH, DIZZ, NAUS,
DROW, & SHORTNESS OF BREATH. SKIN: NO IRRIT IS LIKELY TO DEVELOP
FOLLOWING SHORT CONT PERIODS W/ HUMAN SKIN. PRLNG/RPTD EXPOS CAN
LEAD TO REDNESS, SWELL & NECROSIS. EYES: CAN INDUCE PAIN & MOD
IRRIT. (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ: SKIN ABSORPTION: ADVERSE SYSTEMIC
EFTS CAN DEVELOP FOLLOWING RPTD/PRLNG CONT W/HUMAN SKIN. INGEST: A
SINGLE DOSE OF THIS PROD IS MOD TOX BY INGEST. CHRONIC: INHAL OF
HIGH CONCS OF VAP CAN IN DUCE ANEMIA, LIVER & KIDNEY INJURY &
CLOUDING OF CORNEA. ANIMAL STUDIES CLEARLY DEMONSTRATED
DOSE-RELATED (SUP DAT)
Medical Cond Aggravated by Exposure:LUNG DISEASE.

First Aid:SKIN: REMOVE CONTAM CLTHG & FOOTWEAR. WASH MATL OFF SKIN
W/SOAP & WATER. IF REDNESS, ITCH/BURNING SENSATION DEVELOPS, GET
MED ATTN. WASH CONTAM CLTHG & DECONTAM FOOTWEAR BEFORE REUSE. EYES:
IMMED FLUS H W/WATER FOR AT LEAST 15 MIN & HAVE EYES EXAMINED &
TREATED BY MED PERS. INGEST: GIVE 1-2 GLASSES OF WATER TO DRINK.
INDUCE VOMIT. REFER VICTIM TO MED PERS. INHAL: REMOVE TO FRESH AIR.
(SUP DAT)

Flash Point Method:CC
Flash Point:210F,99C
Lower Limits:0.5%
Upper Limits:10.6%
Extinguishing Media:ALCOHOL FOAM, CARBON DIOXIDE, DRY CHEMICAL, WATER
FOG.
Fire Fighting Procedures:WEAR NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:NO UNUSUAL FIRE/EXPLOSION HAZARDS ARE
KNOWN FOR THIS PRODUCT. AS TYPICAL OF CLOSED CONTAINERS CONTAINING
LIQUID, THEY MAY EXPLODE WHEN EXPOSED TO EXTREME HEAT.

Spill Release Procedures:DIKE AND CONTAIN SPILL WITH INERT MATERIALS
(SAND, CLAY, EARTH, ETC). TRANSFER THE LIQUID TO CONTAINERS FOR
RECOVERY OR DISPOSAL. KEEP SPILL OUT OF SEWERS AND OPEN BODIES OF
WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:KEEP FROM FREEZING. KEEP AWAY FROM
HEAT AND OPEN FLAME. AVOID BREATHING VAPOR. AVOID CONTACT WITH
EYES, SKIN AND CLOTHING.
Other Precautions:USE WITH ADEQUATE VENTILATION TO MAINTAIN VAPOR
CONCENTRATION BELOW TLV. CONTAINERS MAY BE HAZARDOUS WHEN
EMPTIED-ALL HAZARD PRECAUTIONS MUST BE OBSERVED. KEEP OUT OF REACH
OF CHILDREN!

Respiratory Protection:WHERE ADEQUATE VENTILATION IS MAINTAINED, THE
USE OF RESPIRATORY PROTECTION IS NOT NECESSARY. HOWEVER, IF THE TLV
OF THE PRODUCT OR ANY COMPONENT IS EXCEEDED, USE A NIOSH APPROVED
RESPIRATOR.
Ventilation:PROVIDE GENERAL AND/OR LOCAL EXHAUST VENTILATION TO CONTROL
AIRBORNE LEVELS BELOW THE EXPOSURE GUIDELINES.
Protective Gloves:IMPERVIOUS GLOVES FOR REPEATED CONTACT.
Eye Protection:ANSI APPRVD CHEM WORKERS GOGGLES .
Other Protective Equipment:ANSI APPROVED EMER EYEWASH & DELUGE SHOWER .
WEAR IMPERVIOUS CLOTHING & SHOES TO PREVENT RPTD/PRLNG SKIN
CONTACT.
Work Hygienic Practices:REMOVE CONTAMINATED CLOTHING IMMEDIATELY. WASH
SKIN AREA WITH SOAP AND WATER. LAUNDER CLOTHES BEFORE REUSE.
Supplemental Safety and Health
EFTS OF OVEREXP: ADVERSE EFTS ON CNS, HEMATOPOIETIC TISS, BLOOD,
KIDNEYS, & LIVER, ASSOC W/ADMIN OF ETHYLENE GLYCOL MONOBUTYL ETHER
(EGBE) (EXTRACTED FROM DHHS (NIOSH) PUBLICATION #90-118) . FIR ST
AID PROC: IF COUGH/OTHER RESP SYMPS DEVELOP, CONSULT MED PERS.

Boiling Pt:B.P. Text:>212F,>100C
Vapor Pres:SEE INGS
Vapor Density:HVR/AIR
Spec Gravity:1.0 (H*2O=1)
VOC Pounds/Gallon:266
VOC Grams/Liter:2.22
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:MISCIBLE
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER

Stability Indicator/Materials to Avoid:YES
OXIDIZING MATERIAL.
Stability Condition to Avoid:EXCESSIVE HEAT.
Hazardous Decomposition Products:CARBON DIOXIDE, CARBON MONOXIDE.

Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH ALL LOCAL, STATE
AND FEDERAL REQUIREMENTS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.